| The increase in demand for fuels, along with the concerns over the depletion of fossil fuels and the environmental problems associated with the use of the petroleum-based fuels, has driven the exploitation of clean and renewable energy. Through a collaboration project with Mendota Bioenergy LLC to produce advanced biofuel from sugar beet and other locally grown crops in the Central Valley of California through demonstration and commercial-scale biorefineries, the present study focused on the investigation of selected potential biomass as biofuel feedstock and development of bioconversion systems for sustainable biofuel production. For an efficient biomass-to-biofuel conversion process, three important steps, which are central to this research, must be considered: feedstock characterization, enzymatic hydrolysis of the feedstock, and the bioconversion process.;The first part of the research focused on the characterization of various lignocellulosic biomass as feedstocks and investigated their potential ethanol yields. Physical characteristics and chemical composition were analyzed for four sugar beet varieties, three melon varieties, tomato, Jose tall wheatgrass, wheat hay, and wheat straw. Melons and tomato are those products discarded by the growers or processors due to poor quality. The mass-based ethanol potential of each feedstock was determined based on the composition. The high sugar-containing feedstocks are sugar beet roots, melons, and tomato, containing 72%, 63%, and 42% average soluble sugars on a dry basis, respectively. Thus, for these crops, the soluble sugars are the main substrate for ethanol production. The potential ethanol yields, on average, for sugar beet roots, melons, and tomato are 591, 526, and 448 L ethanol/metric ton dry basis (d.b.), respectively. Lignocellulosic biomass, including Jose Tall wheatgrass and wheat straw, are composed primarily of cellulose (27-39% d.b.) and hemicellulose (26-30% d.b.). The ethanol yields from these materials can range from 470 to 533 L ethanol/metric ton (d.b.) Sugar beet leaves contain nearly equal amounts of cellulose (13%), hemicellulose (16%), and pectin (17%). The potential ethanol yield of sugar beet leaves is 340 L ethanol/metric ton (d.b.).;As remaining unused in great quantities during the production of sugar beet as a sugar and energy crop, sugar beet leaves was studied as a potential feedstock for the production of biofuel and valuable products. The enzymatic hydrolysis of sugar beet leaves was optimized for fermentable sugar production. Optimization of enzyme usage was performed to make the biorefinery process more cost- and energy-effective. In this research, response surface methodology was used to study the effects of enzyme loadings during the hydrolysis of sugar beet leaves at 10% total solids content, using a mix of cellulases, hemicellulases, and pectinases. The effects of enzyme loadings were studied with a five-level rotatable central composite design for maximum conversion of sugar beet leaves to fermentable sugars.;The last part of this study investigated biogas production through the anaerobic digestion of microalgae as they have received much attention as another potential biofuel feedstock. Anaerobic digestion of Spirulina ( Arthrospira platensis) was conducted in batch reactors for the study of the kinetics and, in continuous stirred tank reactors (CSTR), for the study of the two important operating parameters: hydraulic retention time (HRT) and organic loading rate (OLR). The kinetics study on methane production from batch experiments shows first order kinetics and a reaction rate constant of 0.382 d-1. The maximum biogas and methane yields for Spirulina are 0.514 L/gVS and 0.360 L CH4/gVS, respectively. The methane content of the biogas is 68%. During the continuous anaerobic digestion in CSTR for OLR in the range of 1.0-4.0 gVS/L/d, biogas and methane yields are in the ranges of 0.276-0.502 L/ gVS and 0.163-0.342 L CH4/gVS, respectively. Methane content is 59-70% of the biogas. Methane yield decreases with an increase in OLR and a decrease in HRT. The maximum methane production is 0.342 L CH4/gVS at OLR of 1.0 gVS/L d and 25d-HRT, achieving 94% of the maximum yield produced by batch digestion. Ammonia inhibition and the accumulation of volatile fatty acids (VFA) were observed at high OLR. According to the results from the continuous digestion of Spirulina, the recommended HRT should be sufficient at least 15d, with the OLRmax of 2.0 gVS/L to prevent ammonia inhibition at higher feed concentrations. The OLR can be increased when the digester is operated at longer HRT since a long HRT provides a more stable operation. A mathematical model, based on the kinetics study from the batch process, was developed for the prediction of methane production during a continuous digestion process, in relation to HRT. Further improvement of the model may have to include the effects of ammonia inhibition and low solids retention time (SRT) to overcome these limitations. (Abstract shortened by UMI.). |
