An experimental and numerical study of open cavity flows

This work is part of an ongoing study aimed at understanding of cavity flow oscillations. An experimental setup was designed, constructed, and tested to measure the Sound Pressure Levels (SPL) on the floor of four cavities, and to quantitatively visualize the flow-field inside the cavity. Measurements were made for a fixed cavity width by depth ratio of 3.33, for four length by depth (L/D) ratios of 2.0, 2.5, 3.5 and 4.5. Using Particle Image Velocimetry (PIV), the cavity velocity fields were obtained at subsonic speeds ranging from Mach 0.3 to Mach 0.6. Numerical simulations were performed for cavity geometry configurations and for flows corresponding to the experiments. Numerical simulations were carried out using a commercial code called CFD-ACE (U) RTM. Results of the simulations were used for comparison with experimental data. Numerical simulations led to further understanding of the mechanism of cavity oscillations.; Experimentally obtained dynamic pressure data show that for cavity with L/D = 2.5, the onset of oscillations occurs at a freestream Mach number of about 0.5. The measured cavity oscillation frequencies were in excellent agreement with the frequencies predicted by the modified Rossiter's semi-empirical formula. Sound Pressure Level peaks between the freestream Mach numbers of M = 0.57 and 0.6 exhibited the phenomenon of mode switching. Mode switching occurs when the dominant frequency of the cavity is changed from one mode to another with small changes in the freestream flow conditions. Onset of oscillations for cavity L/D = 4.5 occurred at a freestream Mach number of about 0.6 and the cavity oscillation frequencies were in good agreement with the frequencies predicted by the modified Rossiter's semi-empirical formula.; Post-processing of the PIV velocity data provided velocity, vorticity, turbulence intensity, and Reynolds stress information in the measurement region. Non-dimensional vorticity contours showed the formation of shear layer (vorticity) immediately downstream of the cavity leading edge and its growth (convection) downstream. For cavity L/D = 2.5 and L/D = 4.5, the vorticity plots showed no organized vorticity structures in the shear layer at a freestream Mach number of 0.4. This corresponded to the absence of a large peak in the SPL for either of the cavity L/D ratios at a freestream Mach number of 0.4. On the other hand, for a Mach number of 0.6 vorticity plots for both displayed relatively well-organized vorticity structures in the shear layer. This finding was consistent with the well-defined SPL peak that was observed for both L/D ratios at this Mach number. (Abstract shortened by UMI.)...